Rancang Bangun Alat Filterasi Limbah Minyak Pelumas (Oli Bekas) Menggunakan Pasir Zeolit, Karbon Altif Dan Membran Keramik

Muhammad Rinaldy Kusnadi, Iwan Nugraha Gusniar, Kardiman Kardiman

Abstract


The increasing use of motor vehicles, the greater the amount of engine oil consumption. Engine oil cannot be used continuously due to frictional force on the engine, so engine oil is purified. Unused engine oil can pollute the environment because it is categorized as B3 waste. Used engine oil has a higher metal content than new engine oil. The reduction in metal content can be done by using a filtration column containing zeolite and activated carbon with a filtration column height of 20 cm from each media. Besides filtering also used separation by using a ceramic membrane. In the use of filtration columns filtering used oil using zeolite and activated carbon after that continued using a ceramic membrane, before the used oil is heated at a temperature of 700 C then flowed on the ceramic membrane. In this research, a decrease in levels of aluminum (Al), iron (Fe), manganese (Mn), copper (Cu), and zinc (Zn) was obtained.


Keywords


Metals, Filtration Column, Ceramic Membrane, Used Engine Oil.

Full Text:

PDF

References


A. R. Nasution, Z. Fuadi, I. Hasanuddin, and R. Kurniawan, Effect of vegetable oils as cutting fluid on wear of carbide cutting tool insert in a milling process, IOP Conf. Ser. Mater. Sci. Eng., vol. 796, no. 1, 2020, doi: 10.1088/1757-899X/796/1/012001.

A. R. Nasution, Affandi., and Z. Fuadi, Pengaruh Cairan Pendingin Terhadap Kekasaran Permukaan Benda Kerja Pada Proses Face Milling, J. Rekayasa Mater. Manufaktur dan Energi, vol. 3, no. 1, pp. 1622, 2019, doi: doi.org/10.30596/rmme.v3i1.4524.

A. Supriyanto, Alimuddin, and Bohari, Analisis Logam Fe , Cu , Pb , Dan Zn Dalam Minyak Pelumas Baru Dan Bekas Menggunakan X-Ray Fluorescence, J. At., vol. 03, no. 1, pp. 15, 2018.

P. Susmanto, J. P. S, and A. Rumaiza, Pengolahan Air Rawa Menjadi Air Bersih di Daerah Timbangan Indralaya (-3,201341 LS 104,6513881 BT) Menggunakan Membran Ultrafiltrasi, Pros. Semin. Nas. Avoer VI, Univ. Sriwij. 30 - 31 Oktober 2014, 2014, [Online]. Available: http://eprints.unsri.ac.id/id/eprint/5328.

A. Anggita and H. -, Aplikasi Serat Optik Sebagai Sensor Kekentalan Oli Mesran Sae 20W-50 Berbasis Perubahan Temperatur, J. Fis. Unand, vol. 4, no. 3, pp. 239246, 2015, doi: 10.25077/jfu.4.3.

A. Rahman, Uji Pemakaian Pelumas Mesran SAE 40 Pada Sistim Transimisi Kotak Roda Gigi Mesin Bubut Maximat V13, Ind. Res. Work. Natl. Semin., vol. 2, pp. 978980, 2012.

A. Kuncoro, S. Wisnugroho, L. Perekayasaan, T. Kelautan, M. Diesel, and F. Blaster, Filter Blaster Untuk Mengurangi Pencemaran Pada Air Laut Di Perairan Semarang, no. September, pp. 120130, 2017.

S. Nasir et al., Perangkat Ultrafiltrasi Untuk Pengolahan Air Sumur Bor Menjadi Air Bersih Di Kelurahan Sukajadi, no. November, pp. 1819, 2020.

M. Dahlan, A. Setiawan, and A. Rosyada, Pemisahan Oli Bekas dengan Menggunakan Kolom Filtrasi dan Membran Keramik Berbahan Baku Zeolit dan Lempung, J. Tek. Kim. Univ. Sriwij., vol. 20, no. 1, pp. 3845, 2014.

S. Nasir, F. Dina, and I. M. A. Dewata, Kinerja membran keramik berbasis tanah liat, zeolit dan serbuk besi dalam penurunan kadar fenol, J. Tek. Kim., vol. 19, no. 3, pp. 3137, 2013.




DOI: https://doi.org/10.30596/rmme.v4i2.8070

Refbacks

  • There are currently no refbacks.


Creative Commons License

 This work is licensed under a Creative Commons Attribution 3.0 License

Jurnal Rekayasa Material, Manufaktur dan Energi  is abstracting & indexing in the following databases: 

 

Creative Commons License

This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.

Statcounter View My Stats RMME